Eurocopter MBB-BK crash near Cherry Point, NC, United States

HISTORY OF FLIGHT On December 29, 2010, at 0223 eastern standard time, a Eurocopter BK117-C2, N854EC, operated by Air Methods Corporation, was landed hard during an emergency landing at Cherry Point Marine Corps Air Station (Cunningham Field) (NKT), Cherry Point, North Carolina, after the pilot became partially incapacitated. The helicopter departed from Pitt County Memorial Hospital Heliport (NC91), Greenville, North Carolina at 0135 and was enroute to Carteret General Hospital, Morehead City, North Carolina. Night visual meteorological conditions prevailed and a company visual flight rules flight plan was filed. The certificated airline transport pilot suffered a medical incapacitation and the two medical flight crewmembers were not injured. The helicopter sustained substantial damage including the landing gear cross tubes. The flight was operated under the provisions of 14 Code of Federal Regulations Part 135. According to an interview provided to the Federal Aviation Administration (FAA), the pilot reported that they were "about two-thousand feet and about three to four minutes out" from the destination. He was flying the helicopter utilizing the autopilot and shortly after "I disengaged the autopilot, my right arm fell to my side." He informed his medical flight crewmembers as well as the Cherry Point Air Traffic Controller and declared an emergency. He further requested to land at NKT and the Air Traffic Controller provided radar vectors. A medical crewmember seated in the left front seat manipulated the collective control with the pilot's instructions and the pilot manipulated the cyclic control with his left hand. The pilot elected to make a run on landing and upon contact with the runway, the helicopter became airborne again, and then touched down again. According to a written statement provided by the secondary nurse seated in the left front seat, the flight had been a very smooth and uneventful flight. They were at 2,600 feet and preparing for descent into the hospital landing zone when the pilot stated that "he could not move his right arm." The pilot reported that he did not have any other symptoms or weakness but "his speech was becoming a bit slurred." During the flight to NKT the pilot had requested assistance from the secondary nurse. As the flight approached the airport, the nurse reported that the main runway was lit and they had been given directions to it. She further reported that even though she pointed towards the airport the pilot was unable to identify the runway and the flight subsequently flew over it. The controller vectored the helicopter back to the airport and the pilot subsequently acquired the airport. After landing, the primary flight nurse exited the helicopter to assist the pilot with the engine shutdown procedure. Emergency personnel that responded to the scene assisted the pilot out of the helicopter onto a stretcher for transport to a local hospital. PERSONNEL INFORMATION According to FAA and company documentation, the pilot, age 61, held an Airline Transport pilot certificate for helicopter and airplane single-engine land, with ratings for instrument airplane and helicopter. His most recent FAA second class medical certificate was issued on August 12, 2010, which contained some limitations including "not valid for any class after August 31, 2011." He had approximately 11,000 total hours of flight experience, 17 total hours of flight experience in make and model of the accident helicopter, and had flown 2 hours in the proceeding 24 hours prior to the accident. His most recent flight review was conducted on December 2, 2010, and was in the accident helicopter make and model. AIRCRAFT INFORMATION The helicopter was issued an FAA special airworthiness certificate on October 8, 2010, and was registered to the owner on June 28, 2010. It was equipped with two Turbomeca Arriel 1E2 engines. On December 24, 2010, the helicopter had undergone and inspection in accordance with an approved inspection program. At the time of the accident the helicopter and engines had each accumulated 121 hours total time in service. METEOROLOGICAL INFORMATION The 0154 recorded weather observation at NKT included wind from 260 degrees at 7 knots, visibility 10 miles, clear skies, temperature minus 1 degree C, dew point minus 7 degrees C, and an altimeter setting of 30.12 inches of mercury. COMMUNICATIONS About 0210, the pilot declared an emergency with Cherry Point Approach control. According to a transcript of the recording, the pilot reported to approach control that he had a medical problem and was having "trouble flying the aircraft." The controller reported to the pilot that their position was about one mile north of another airport and approximately 12 miles from NKT. The pilot requested and received clearance to proceed directly to NKT. About 0214, the pilot requested an instrument landing system (ILS) approach to the airport. The controller stated that the ILS was to runway 23. About 0219, the helicopter was approximately one miles south of NKT, subsequently overflew the airport, and was vectored by the controller for runway 32R. After completion of the turn back towards the airport, and about 0222 the pilot reported he had the airport in sight. AIRPORT INFORMATION The airport was equipped with a four runways; two runways were oriented southeast to northwest and designated as 14L/32R and 14R/32L, and two runways were oriented southeast to northwest and designated as 5L/23R and 5R/23L. The helicopter landed on runway 14L which was 8,984-feet-long and 200-feet-wide, constructed of asphalt, and was equipped with high intensity runway edge lights. The airport did have a Marine Corps staffed air traffic control tower which was operational and staffed at the time of the accident. WRECKAGE AND IMPACT INFORMATION According to photographs provided by an FAA inspector that responded to accident location, the helicopter stopped on the runway approximately 4,000 feet from the approach end of runway 14L. The helicopter's right vertical stabilizer was scraped along the bottom edge and substantial damage was done to the landing gear crosstubes which were bowed downward. MEDICAL AND PATHOLOGICAL INFORMATION The pilot’s FAA medical records dated prior to the accident documented that the pilot experienced a small ischemic stroke in the left thalamus on July 20, 2006. The pilot was hospitalized with right leg and arm heaviness and numbness, but recovered quickly with only abnormal sensation over the right forearm by July 25, 2006. No specific etiology was identified, though the pilot was noted to have a history of high cholesterol, and a family history of stroke. His neurologist noted a history of high cholesterol and recommended aspirin and a cholesterol-reducing medication to reduce his risk of stroke. At the time of his application for an FAA airman medical certificate on September 3, 2008, the pilot was noted not to be on a cholesterol-reducing medication (because his cholesterol was "good"), but was noted to be on aspirin and a combination blood pressure medication (for "borderline high blood pressure"). His height and weight were noted as 68 inches and 240 pounds on that application, and on two subsequent applications. The pilot was given an Authorization for Special Issuance of a second-class medical certificate on September 26, 2008. The pilot was given another Authorization for Special Issuance of a second-class medical certificate on September 17, 2009, in conjunction with an application for airman medical certificate on August 27, 2009, indicating the same height, weight, and medications. The pilot’s most recent medical certificate was issued on August 12, 2010 by his aviation medical examiner "in accordance with Authorization." FAA medical records included reports of a normal but "technically difficult" transthoracic echocardiogram, a normal magnetic resonance angiogram, an essentially normal exercise treadmill test, an